GTO GP-SW050 Safety Gate User Manual


  Open as PDF
of 37
 
7
Technical Specications
Motor
•BrushlessDCmotor24VDC300watts
•½Horsepower
•Maximummotorcurrent20Amp
•2500RPM
•Openandclosetimefor90°openingisapproximately15seconds
Gear Reducer
•AluminumCased1200:1,size40/63,compound,wormreducerwithballbearings.
•Permanentlylubricatedwithsyntheticgearoil–oilspecications5w-30,Mobil1recommended
Power
•120vac@60Hzwithinherent24vdcbatterybackup
•Batteriesarerequired–two12vdc,U1,230Aminimumcoldcrankampswiredtogetherinseries.
•100cyclesinbackuptypicalforminimumsizebattery.
•15ampcircuitbreakerondedicatedcircuit
•Onboard120vacoutletforaccessoriesthatpullnomorethan1ampofcurrent
Control
•Microcontrollerbasedlogiccontrolboard
•Adjustableautoclose
•Independentobstructionsettings
•DiagnosticLED’s&AudibleAlarms
•Accessoryterminalscompatiblewithloopdetectors,photobeams,edgesensors,pushbuttons,cardreaders,exitwands,etc.
•RelayOutputs
•OnboardOpenandClosedStopbuttons
•JogButtons
Construction
•Heavydutysteelframe
•RotomoldedUVstabilizedHDPEcover
Operational Capacity
•Continuousdutyoperations
•Maxrating:16ftgate@650lbs
•DualGatecompatibleusingtwoconductor22AWGshieldedwireratedfordirectburial.Recommended
BeldenWire®,22AWG,type8761,9461,9451,1266Aorequivalent.1-pairshieldedwithdrainwire.Availableatyour
local electrical supply store.
Dimensions
•HousingDimensions:height33in(68.7cm),depth18in(45.7cm),width15in(38cm),shippingweight:130lbs
•ConcretePadDimensions:18inx18in,(45.7cmx45.7cm).Consultlocalbuildingcodesfordepthbelow
groundlevel.Absoluteminimumdepth30in(76.2cm)belowgroundlevel.
Operational Temperature:
•Incolderclimates(ambienttemperatureslessthan10degrees)GTOrecommendstheuseofathermostatically
controlled heating source (ceramic heating strips, etc.) on the batteries and gearbox assembly. Styles, types,
andpowerrequirementsofheatingdeviceswillvarybyclimateandregion.
Warranty:
•Residential (7) years for mechanical parts, (5) years electronic components
•Commercial (5) years for mechanical parts, (3) years electronic components
 previous next