Filter
Top Products
3
V700 Windlass
GB
Contents
65001022 Issue 2. V700 Windlass.
To the best of our knowledge, the information in this manual
was correct when it went to press. However, Lewmar cannot
accept liability for any inaccuracies or omissions it may contain.
In addition, our policy of continuous product improvement may
change specifi cations without notice. As a result, Lewmar cannot
accept liability for any differences between the product and the
manual.
This manual forms part of the product and MUST BE RETAINED
along with, OR incorporated into, the Owner’s Manual for the vessel
to which the windlass is fi tted.
Introduction 4
Product support 4
Approvals 4
Safety notices 4
General 4
Electrical 4
Electromagnetic compatibility 4
Important information about this manual 4
1. Installation 5
1.1 Gypsy Suitability 5
1.2 Package contents 5
1.3 Additional requirements 5
1.4 Accessories 5
1.5 Specifi cations 5
1.6 Fitting the windlass to the deck 5
2. Electrical wiring installation 7
2.1 Electric cable selection 7
2.2 Wiring 7
2.3 Control switch installation 7
2.4 V700 Wiring diagram (toggle switch) 8
2.5 V700 Wiring diagram (contactor) 8
3. Operating your windlass 9
3.1 Safety fi rst 9
3.2 Use of clutch 9
3.3 Letting go under gravity 9
3.4 Letting go under power 9
3.5 Lying to anchor safely 9
3.6 Hauling in 9
3.7 Manual recovery 9
3.8 Operating tips 9
3.9 Joining rope to chain 9
4. Maintenance 10
4.1 General recommendations 10
5. Dismantling procedures 10
5.1 Gypsy replacement 10
5.2 Control arm replacement 10
5.3 Main shaft lubrication 10
5.4 Fall safe pawl replacement 10
5.5 Fall safe lever replacement 10
6. Troubleshooting 11
6.1 Anchor rode pays out independently while
windlass is not in use 11
6.2 Electrical troubleshooting 11
7. Parts list 12
7.1 Service kits 13
7.2 Parts list key 13
8. Lewmar limited warranty 14