Filter
Top Products
Congratulations!
Your Burley
®
trailer is the leading choice of refined bicycle
trailer owners worldwide. Every effort has been made to
ensure your purchase is a top-quality, thoroughly-tested
design, ready to provide many years and miles of happy,
safe trailering.
Please go to www.burley.com or contact us at
burley@burley.com to register your warranty information.
Introduction
Once you’ve done the initial assembly and read the safety
guidelines, you’re ready to go! Before trailering, be sure you
have the safety harness, seat belt, tow bar, trailer wheels and
hitch securely attached.
Note: Any reference to left or right is made in direction of
travel, as if you were standing behind the trailer,
looking forward.
Safety Guidelines
1. Inspect and maintain your bicycle and trailer regularly. See
“Safety Checklists” on page 10.
2. Because of the trailer’s additional weight, a bicycle pulling
a trailer is heavier and less responsive. Avoid sudden
swerving, rocks and curbs. Experiment with the loaded
trailer in an uncongested area until you become familiar
with it.
3. The total weight limit for the trailer, children and/or cargo
is 100 lbs (40 kg by law in Europe). Load children and/or
cargo securely in the center of the trailer, forward of the
axle and as low as possible.
4. The trailer seat is intended for 1 or 2 children who are
old enough to wear a helmet, sit upright without physical
support, and with adequate neck strength to hold their
heads upright while trailering, unless using Burley-
approved infant accessory seat. A physician should
evaluate anyone who is of questionable developmental age
for trailering.
Note: Go to www.burley.com to see Burley’s line of infant
seats and adapters for younger children.
5. The maximum age for passengers is 6 years. Never carry
children whose seated height (with helmet) exceeds 4
inches (100mm) below the internal roll bar.
6. Fasten the seat belt and shoulder harnesses so that each
child is held securely. Seat a single child in the center.
Periodically check the placement of the shoulder straps,
especially on sleeping children.
7. Make sure children cannot put a finger into the wheel
spokes.
8. Instruct children not to bounce or lean, as a weight shift
could cause the trailer to tip over.
9. To protect children from flying debris, always use your
cover. Never leave children unattended. Check children
frequently, especially during hot or cold weather.
10. Observe recommended speed limits: a maximum of
15 mph (24 km/h) on smooth, straight roads and
5 mph (8 km/h) or less when turning or on uneven roads.
11. Set your parking brake before removing your children
or cargo.
12. Never pull your trailer with a motorized vehicle.
13. The cyclist and passengers must wear helmets.
14. Only use factory-supplied wheels, with the tires inflated
to the pressure recommended on the tire side wall. Check
pressure before each use. Do not use higher-pressure or
knobby tires.
15. Clamp the hitch securely to the bicycle frame, and check
for a tight attachment before each ride.
16. Use the safety flag.
17. Do not make alterations to the trailer. Contact your
Authorized Burley Dealer or go to www.burley.com for
replacement of any damaged, worn-out or missing parts.
18. Do not use your trailer on icy roads or when inclement
weather makes cycling hazardous.
19. The use of a mirror on your bicycle is recommended.
20. For emergencies, breakdowns or flat tires, pull completely
off the road and move your children to a safe area before
doing repairs.
Parts Bag Contents:
(1) Burley Owner’s Instruction and Safety Manual
(1) Hitch
(2) Red reflectors with screws
(2) Reflector brackets
(1) Wheel guard assembly:
(2) wheel guards, (4) screws
(1) Handle bar receiver set:
(2) handle bar receiver pairs, (2) knobs, (4) screws, (4) lock nuts
Tools Required: Phillips screwdriver
5mm hex wrench (provided)
B U RL EY H ON EY B E E OW NE R’ S I NS TR UC TI ON A ND S AF ET Y M AN UA L 3
IMPORTANT
IT IS VERY IMPORTANT FOR YOU TO FAMILIARIZE YOURSELF WITH
YOUR BURLEY BY READING THIS ENTIRE MANUAL BEFORE USE.
IF YOU HAVE ANY QUESTIONS, PLEASE CONTACT YOUR
AUTHORIZED BURLEY DEALER OR VISIT WWW.BURLEY.COM.
BICYCLING WITH A TRAILER, AND BICYCLING IN GENERAL, CAN
BE HAZARDOUS. FAILURE TO OBSERVE ANY OF THE SAFETY
GUIDELINES IN THIS MANUAL COULD RESULT IN AN ACCIDENT
AND SERIOUS INJURY OR DEATH.
WARNING